Scotsman MC 45 Wartungshandbuch PDF herunterladen (Seite 37)

Page 37

Rx Tx

WATER IN VALVE

HOT GAS VALVE

FAN MOTOR

WATER PUMP

- EVAPORATOR

- AMBIENT

- CONDENSER

TEMPERATURE SENSORSBINCOMPRESSOR

TRANSF.

DATA

PROCESSOR

ELECTR.

TIMER

DIP

SWITCH

ELECTRONIC CARD

RELAYS

RELAY

TRIAC

WATER DRAIN VALVE

CONTACTOR COIL

FIG. 8

9. Flush out the cleaning solution from the

sump reservoir then pour onto the evaporator

cavity two or three liters of clean potable water to

rinse the mold cups and the platen.

lf necessary remove the water spray bar to clean

it separately as per steps 3 and 4 of paragraph B.

10. Turn again the program selector on

CLEANING/RINSING. The water pump is again

in operation to circulate the water in order to rinse

the entire water system.

11. Do it twice so to be sure no more traces of

descaling solution remains into the sump.

12. Pour on the upper side of the evaporator

platen fresh water with a capfull of disinfectant

solution then turn again the machine in cleaning

mode so to sanitize all the water system for

approx. 10 minutes.

NOTE. DonotmÌxdescalÌngwithdisinfectant

solution to avoid the generation of a very

aggressive acid.

13. Flush out the rinsing water from the sump

reservoir then turn the program selector on

RESET/HI TEMPERATURE position and

immediately afterward to FREEZING

OPERATION.

NOTE. By setting the setector on RE-SET

first and then to FREEZING OPERATION

the ice maker will perform the 5 minutes

WATER FILLING phase i.e. the water inlet

solenoid valve opens to allow the incoming

water to rinse again the water system and to

properly fill-up the sump reservoir for the

next freezing cycle.

14. Piace again the evaporator cover and the

unit service panels.

15. At completion of the freezing and harvest

cycle make sure of proper texture and clearness

of the ice cubes and that, they do not have any

acid taste.

ATTENTION. in case the ice cubes are

cloudy, white and have an acid taste, melt

them immediatelly by pouring on them

some warm water. This to prevent that

somebody could use them.

16. Wipe clean and rinse the inner surfaces of

the storage bin.

REMEMBER. To prevent the accumulation

of undesirable bacteria it is necessary to

sanitize the interior of the storage bin with an

anti-algae disinfectant solution every week.

1 2 ... 32 33 34 35 36 37

Kommentare zu diesen Handbüchern

Keine Kommentare

Scotsman MC 45 Wartungshandbuch Seite 37

Kommentare zu diesen Handbüchern

Verwandte Produkte und Handbücher für Eiswürfelmacher Scotsman MC 45