Scotsman CU0715 Wartungshandbuch

Service Manual for Cube Ice Machine with storagemodels CU0415, CU0715 and CU0920

August 2013Page 9Service Manual for Models CU0415, CU0715 and CU0920Ice Bridge Thickness Adjustment AreaMaster Switch. Move to ON (left side depressed

Service Manual for Models CU0415, CU0715 and CU0920August 2013Page 10Initial Start Up1. Remove the front panel by removing the two screws holding it

August 2013Page 11Service Manual for Models CU0415, CU0715 and CU0920Use and Operational NotesTo use, simply lift the door by its bottom edge and slid

Service Manual for Models CU0415, CU0715 and CU0920August 2013Page 12MaintenanceRegularly vacuum the right side of the air cooled condenser with a bru

August 2013Page 13Service Manual for Models CU0415, CU0715 and CU09207. Drain the reservoir into the storage bin by removing the drain plug. Return t

Service Manual for Models CU0415, CU0715 and CU0920August 2013Page 14Electrical SequenceProper voltage must be supplied and the bin thermostat closed

August 2013Page 15Service Manual for Models CU0415, CU0715 and CU0920ComponentsCompressors, three capacities Type: Hermetic Brand: EmbracoCondenser: a

Service Manual for Models CU0415, CU0715 and CU0920August 2013Page 16PerformanceCU0415Compressor amp draw, 115 volt• Freeze, 5 minutes in: 1.8 to 1.9

August 2013Page 17Service Manual for Models CU0415, CU0715 and CU0920Thermistor Values0 853251 826612 800903 776074 752105 728966 706607 685018 664159

Service Manual for Models CU0415, CU0715 and CU0920August 2013Page 18Controller UseWhen in a Freeze cycle or mode, a blue light will glow.The upper li

August 2013Page 1Service Manual for Models CU0415, CU0715 and CU0920IntroductionThe design of this product is the result of years of experience in dev

August 2013Page 19Service Manual for Models CU0415, CU0715 and CU0920Anti-SlushSlushinthereservoirrestrictspumpow,causesexcessively long free

Service Manual for Models CU0415, CU0715 and CU0920August 2013Page 20Controller Self TestControl Board Self-Test Routine. Begin with unit unplugged an

August 2013Page 21Service Manual for Models CU0415, CU0715 and CU0920Service DiagnosisProblem Possible Cause Probable CorrectionNo ice No water to ice

Service Manual for Models CU0415, CU0715 and CU0920August 2013Page 22Service DiagnosisProblem Possible Cause Probable CorrectionNo ice, fan motor not

August 2013Page 23Service Manual for Models CU0415, CU0715 and CU0920Problem Possible Cause Probable CorrectionMakes ice but makes blocks or shells Ic

Service Manual for Models CU0415, CU0715 and CU0920August 2013Page 24Removal and ReplacementCurtain1. Remove front panel and switch unit Off.2. Remo

August 2013Page 25Service Manual for Models CU0415, CU0715 and CU0920Removal and ReplacementPump1. Disconnect electrical power.2. Remove top panel.3

Service Manual for Models CU0415, CU0715 and CU0920August 2013Page 26Removal and ReplacementBin Thermostat1. Disconnect electrical power.2. Remove f

August 2013Page 27Service Manual for Models CU0415, CU0715 and CU0920ControllerThe controller ships set for CU0715 and must be adjusted for other mode

Service Manual for Models CU0415, CU0715 and CU0920August 2013Page 28Cabinet Removal for Service1. Remove front panel.2. Remove top panel.3. Remove

Service Manual for Models CU0415, CU0715 and CU0920August 2013Page 2Important DetailsThe machine is designed for use indoors in a controlled environme

August 2013Page 29Service Manual for Models CU0415, CU0715 and CU0920115/60/1 Wiring DiagramREV. A FUSE (3A) (50Hz only)YRWWWBUGN/YBKorBLYBU/WB/WB/WWo

SCOTSMAN ICE SYSTEMS775 Corporate Woods ParkwayVernon Hills, IL 60061USA847-215-4500800-726-8762www.scotsman-ice.com

August 2013Page 3Service Manual for Models CU0415, CU0715 and CU0920Pre-InstallationThis appliance is intended to be used in commercial applications i

Service Manual for Models CU0415, CU0715 and CU0920August 2013Page 4Cabinet Layout, CU0415 and CU071595.4cm37.6in81.1cm31.9in29.8cm11.8inAIROUTLETAIRI

August 2013Page 5Service Manual for Models CU0415, CU0715 and CU0920Cabinet Layout, CU092095.4cm37.56in42.5cm16.75in81.1cm31.94inAIRINLETAIROUTLET48.3

Service Manual for Models CU0415, CU0715 and CU0920August 2013Page 6Component LocationBin Thermostat AdjustmentCondenser FinsControl AreaDrain PlugBin

August 2013Page 7Service Manual for Models CU0415, CU0715 and CU0920Connect the water supplyPlumbing information:• The water supply connection is at

Service Manual for Models CU0415, CU0715 and CU0920August 2013Page 8Connect the powerThis is a cord-connected unit, and must be connected to its own d